|
ETM Issues Discuss issues regarding the problems with ETMs fitted to Volvo cars. |
Information |
|
ETM failure ?Views : 6587 Replies : 4Users Viewing This Thread : |
|
Thread Tools | Display Modes |
Jun 23rd, 2016, 12:59 | #1 |
Senior Member
Last Online: Jun 2nd, 2019 22:26
Join Date: Jul 2011
Location: Sheerness, Kent
|
ETM failure ?
Good afternoon all.
My in-laws MY2001 V70 2.4 NA threw up a MIL a couple of days back accompanied with intermittent "surges" of power. Urgent engine service appeared on the DIM and the car appears to have gone into limp mode. Recycling the ignition extinguished DIM warning and power returned for a short while before starting to play up again. I connected up VIDA and read the codes from it. They are as follows; ECM-903F THROTTLE POSITION (TP)-SIGNAL MISSING ECM-914F THROTTLE POSTION (TP)-SENSOR 1 AND 2 - FAULTY SIGNAL ECM- 91A7 THROTTLE POSITION (TP)- FAULTY CONTORL ECM-91F0 THROTTLE POSTION (TP)- FAULTY CURRENT ECM-980F- AIR FLOW-FAULTY FLOW I reset the codes and asked my father to drive it. He used it the following day on local b roads with no issues, however whilst putting it on a dual carriage way yesterday, the same symptoms reappeared. I've not yet plugged back into it to verify if the same codes have been generated. (I'll do this, this evening). If the codes are the same as before I'm assuming that the ETM is going to be the most likely culprit here. Is the MAF fault a consequence of the ETM issue ? Whilst visually inspecting under the bonnet on the first instance, I did remove the air filter housing to ETM pipe. The ETM was spotless inside. I've checked for the sticker under the ETM and can confirm it is White. As it stands, I'm going to re-read codes this afternoon. I've read that VIDA can carry out a sweep test on the ETM but that there is no pass/fail result. Is this correct ? Any suggestions would be welcomed. Thanks in advance
__________________
2005 S60 D5
|
Jun 25th, 2016, 20:20 | #2 |
Senior Member
Last Online: Jun 2nd, 2019 22:26
Join Date: Jul 2011
Location: Sheerness, Kent
|
I've hooked back to up to the car and confirmed that all 4 ETM related codes are back. No sweep test activation was available for this car however I was able to very both TP sensor angles feedbacks.
ECM-914F is triggered if the ETM detects that the signals from throttle position sensors 1&2 differ by more than 5% while driving. Now bare with me here. When manually pushing throttle butterfly fully closed pot 1 and 2 read 12.5degrees. When push fully open they read 101 degrees. From fully closed to fully open is 88.5 degrees. 5% of this figure is 4.4degrees. When the butterfly was pushed to approx. mid way, POT 1 read 42.3 degrees and POT 2 read 48.44 degrees. This gap became even greater (closer to 8 degrees) when moving butterfly. Is a symptom of ETM failure revs holding high (around 2000rpm) when throttle is released and engine hunting ? Anyone have any ideas of further tests I can carry out ? Or is it time to get it repaired ?
__________________
2005 S60 D5
|
Jun 25th, 2016, 20:41 | #3 | |
Experienced Member
Last Online: Today 16:03
Join Date: Jun 2007
Location: L/H side
|
Quote:
Yes time for a new ETM , the replacement with yellow label seem pretty trouble free . Or you can risk a repair by a company i guess , but compare prices carefully first between new and a repair .
__________________
My comments are only based on my opinions and vast experience . |
|
Jun 25th, 2016, 21:10 | #4 | |
Senior Member
Last Online: Jun 2nd, 2019 22:26
Join Date: Jul 2011
Location: Sheerness, Kent
|
Quote:
__________________
2005 S60 D5
|
|
Nov 3rd, 2018, 09:27 | #5 |
New Member
Last Online: Nov 12th, 2018 23:05
Join Date: Nov 2018
Location: Kocani
|
Volvo v70 estate II 2.4125kW
Hi, Im new on this forum and I have ETM problems acording to the OBD codes (91F0, 91A7, 91KF)! When I turn on the ignition, there is idiling, and my cruise control turn off by itslef and the car goes to idle mode! Im thinking to change the TPS with contactless, but I dont know if this can relsolve my problem! Here in Macedonia we dont have specialist for Volvo Can somebody help! Thanks
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|