|
S80 '98-'06 / S60 '00-'09 / V70 & XC70 '00-'07 General Forum for the P2-platform S60 / V70 / XC70 / S80 models |
![]() |
|
V70 D5 Just cleaned out my EGR mixer pipe - jesus!!Views : 204028 Replies : 219Users Viewing This Thread : |
![]() |
|
Thread Tools | Display Modes |
|
![]() |
#1 |
Member
Last Online: Oct 21st, 2013 13:02
Join Date: Apr 2010
Location: leeds
|
![]()
Can't believe how much gunk was accumulated in the thing.
I dread to think how messy the top of the engine is. Here's some pics anyway. ![]() The mixer pipe is the metal 90deg pipe in the right of the image. It was well caked in slimey black sooty cr@p. Also the inlet into the top of the engine was thick with the same gunk. Prior to removal ![]() After removal ![]() The EGR inlet hole (I think) ![]() This is the common point for people to blank off the EGR. And after a good clean up ![]() ![]() Cleaned it up using carb cleaner and a LOT of kitchen roll. If you're going to do it invest in some latex gloves as it's a very messy job. Also tried as best as I could to clean out the top of engine inlet pipe and managed to scoop out a lot of mess with my fingers then cleaned out with carb cleaner and kitchen roll. It would really mean taking the top engine cover off to clean out properly but this would take a lot longer and mean messing about with the fuel lines, couldn't be bothered with that. Easy job, just need a screw driver for the jubilee clips, takes an hour max. The car seems to run a little smoother now and throttle response has improved, not a hugely noticable difference but it can't be good for the car to have all that horrible gunky cr@p in there. For info my car is a 2002 V70 D5 on 103k. The question is, would blanking my EGR valve prevent this from building up in future? I'm tempted to leave it be as the car runs fine as is. Last edited by dave_s13; Apr 25th, 2010 at 15:53. |
![]() |
![]() |
The Following 21 Users Say Thank You to dave_s13 For This Useful Post: |
![]() |
#2 |
Junior Member
Last Online: Dec 13th, 2010 09:06
Join Date: Feb 2010
Location: Lancashire
|
![]()
Blanking the EGR would prevent the sooty exhaust gases from getting in there so yes it would stay alot cleaner. The issue is whether your ECU would register an error code due to the blanked off EGR.
I used to have a BMW 330D that I blanked off the EGr and I had no issues with error codes, but that is of course a completely different car. If you consider cleaning it as a yearly service regimen then you could probably skip blanking it and stay on top of the gunge build up. |
![]() |
![]() |
![]() |
#3 |
Lunatic from Wakefield
Last Online: Apr 16th, 2023 06:33
Join Date: Dec 2004
Location: wakefield
|
![]()
did mine last weekend and just as bad as yours, as said you may have issues blanking it of and doing it yearly will not be as bad.
mike
__________________
2012 volvo xc90 Executive Buccaneer Bermuda 2021 |
![]() |
![]() |
![]() |
#4 |
Member
Last Online: Oct 21st, 2013 13:02
Join Date: Apr 2010
Location: leeds
|
![]()
I'm going to leave it alone, it's not broke and all that
![]() Amazing how badly these things crud up though, I wasn't expecting that much! |
![]() |
![]() |
![]() |
#5 |
Senior Member
Last Online: Yesterday 19:15
Join Date: Dec 2008
Location: Lincoln
|
![]()
Hi,
Can you notice any difference in the way the car drives since you cleaned the EGR out? Does it pull better or less smoke.....? I'm amazed how much crap had built up! Cheers, Nobby |
![]() |
![]() |
![]() |
#6 |
Member
Last Online: Oct 21st, 2013 13:02
Join Date: Apr 2010
Location: leeds
|
![]()
The difference is not that pronounced to be honest but it does seem to pull more consistently under hard acceleration. It also seems to start easier, not that it was bad before, fires up after a couple of turns of the engine rather than 3 or 4 and throttle respose seems to have improved.
I think some people have seen an improvement in MPG but it's a bit early for me to see that. Ultimately, if your car has any mileage on it this pipe WILL be full of horrible nasty sheeiite. It makes sense that it would be better off not being there. Dead easy job, just a bit messy. |
![]() |
![]() |
![]() |
#7 | |
Member
Last Online: Oct 21st, 2013 13:02
Join Date: Apr 2010
Location: leeds
|
![]() Quote:
I would imagine it's only worth messing with the valve itself if you are getting error codes? |
|
![]() |
![]() |
![]() |
#8 |
New Member
Last Online: Jun 19th, 2013 12:50
Join Date: Aug 2011
Location: Sherburn in Elmet
|
![]()
So much thanks for this information. I have done the job on my 52 plate s60 d5 and whilst off blanked the EGR . The result is fantastic. It only took me 35 mins to do complete I cleaned the pipes with Petrol and used the top of a bean tin to blank the EGR.
I now have no smoke the car is running so much better I cant explain. No miss fire no flatspot better economy. I owe you a big big thanks as I thought I was in for some big bills. once again thanks for the information and good luck to all you other guys with smoking problems. Jack. |
![]() |
![]() |
![]() |
#9 |
Premier Member
Last Online: Feb 12th, 2023 10:07
Join Date: May 2009
Location: Durham
|
![]()
Thanks to Kira for putting me onto this, i'll be having a look at mine A.S.A.P.
Lets spare a quick thought for all the flood victims up on the east coast of America. |
![]() |
![]() |
The Following User Says Thank You to Rossi-fan For This Useful Post: |
![]() |
#10 | |
Jono
Last Online: May 21st, 2020 06:36
Join Date: Apr 2006
Location: Norwich
|
![]() Quote:
__________________
|
|
![]() |
![]() |
![]() |
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|